- Department of Surgical Sciences, Post Graduation Program in Medicine, Porto Alegre Clinical Hospital, Federal University of Rio Grande do Sul, Porto Alegre, RS, Brazil
- Department of Plastic and Craniomaxillofacial Surgery, Porto Alegre Clinical Hospital, Federal University of Rio Grande do Sul, Porto Alegre, RS, Brazil
- Neurosurgery Department of Cristo Redentor Hospital, Porto Alegre, Rio Grande do Sul, Brazil
- Cerebral Ischemia Laboratory, Department of Biochemistry, Federal University of Rio Grande do Sul, Rio Grande do Sul, Brazil
Paulo Valdeci Worm
Department of Surgical Sciences, Post Graduation Program in Medicine, Porto Alegre Clinical Hospital, Federal University of Rio Grande do Sul, Porto Alegre, RS, Brazil
Department of Plastic and Craniomaxillofacial Surgery, Porto Alegre Clinical Hospital, Federal University of Rio Grande do Sul, Porto Alegre, RS, Brazil
DOI:10.4103/2152-7806.193725Copyright: © 2016 Surgical Neurology International This is an open access article distributed under the terms of the Creative Commons Attribution-NonCommercial-ShareAlike 3.0 License, which allows others to remix, tweak, and build upon the work non-commercially, as long as the author is credited and the new creations are licensed under the identical terms.
How to cite this article: Worm PV, do Nascimento TL, Couto Nicola Fd, Sanches EF, Santos Moreira CF d, Luiz Pedro Willimann Rogério, dos Reis MM, Finger G, Martins Collares MV. Polymethylmethacrylate imbedded with antibiotics cranioplasty: An infection solution for moderate and large defects reconstruction?. Surg Neurol Int 09-Nov-2016;7:
How to cite this URL: Worm PV, do Nascimento TL, Couto Nicola Fd, Sanches EF, Santos Moreira CF d, Luiz Pedro Willimann Rogério, dos Reis MM, Finger G, Martins Collares MV. Polymethylmethacrylate imbedded with antibiotics cranioplasty: An infection solution for moderate and large defects reconstruction?. Surg Neurol Int 09-Nov-2016;7:. Available from: http://surgicalneurologyint.com/surgicalint_articles/polymethylmethacrylate-imbedded-antibiotics-cranioplasty-infection-solution-moderate-large-defects-reconstruction/
Background:In cases where autologous bone graft reconstruction is not possible (such as comminuted fractures, bone graft reabsorption, or infection) and the use of synthetic material is required, polymethylmethacrylate (PMMA) use is a safe and efficient solution. Studies comparing the incidence of postoperative complications between autologous and synthetic cranioplasty are heterogeneous, not allowing a conclusion of which is the best material for skull defects reconstruction. Current medical literature lacks prospective well-delineated studies with long-term follow-up that analyze the impact of antibiotic use in PMMA cranial reconstruction of moderate and large defects.
Methods:A prospective series of patients, who underwent cranioplasty reconstruction with PMMA impregnated with antibiotic, were followed for 2 years. Authors collected data regarding demographic status, clinical conditions, surgical information, and its complications.
Results:A total of 58 patients completed full follow-up with a mean group age of 40 years and a male predominance (77%). Major complications that required surgical management were identified in 5 patients, and 10 patients evolved with minor complications. Postoperative surgical site infection incidence was 3.2%.
Conclusion:The infection rate in patients submitted to PMMA flap cranioplasty impregnated with antibiotic is significantly inferior comparing to the data described in medical literature. A lower infection incidence impacts secondary endpoints such as minimizing surgical morbidity, mortality, hospitalization period, and, consequently, costs.
Keywords: Cranioplast, infection, methylmethacrylate, neurosurgical procedures, postoperative complications, skull fractures
Decompressive craniectomy is a surgery commonly performed in patients suffering from severe head injury or massive brain hemorraghe, representing, in most cases, the chance for patient survival.[
Elective cranial reconstruction has a higher infection rate when compared to other elective neurosurgical procedures independent of the material used for cranioplasty. Autologous bone cranioplasty has a lower incidence of postoperative infection when compared to synthetic prothesis, whose infection incidence may be as high as 20%.[
Authors conducted an interventional, clinical, longitudinal, prospective, and noncontrolled study with allocation of 58 patients with cranial failure of multiple causes between March 2012 and May 2015. Patients were selected continuously by spontaneous ambulatory demand in a tertiary hospital of high complexity, specialized in head and spinal trauma in southern Brazil, where the historic rate of infection in skull prostheses reaches 20%. Data regarding patient’s clinical and neurological conditions, defect topography, comorbidities, reconstruction size, previous and current imaging examinations, and detailed clinical history of previous hospitalization, including the reason for craniectomy, were collected.
All patients were submitted to the standard cranioplasty surgery with PMMA model. Furthermore, infection prophylaxis was performed with intravenous 2 g Cefazolin injected during anesthesia induction. We used PMMA impregnated with erythromycin 0.5 g and colistin 3.00 million IU. All patients remained for 24–48 hours with an epidural drain. The defect size was calculated on a GE workstation with Advantage Workstation software 4.4, and were classified as small (<75 cm2), moderate (75–125 cm2), or large (>125 cm2), according to previous studies.[
The study was approved by the hospital committee of ethics in research, and a completed consent form was collected from all participating patients and/or their parents.
A total of 58 patients were included in the study, with a higher proportion of males (75.58%) and a global mean age of 40 ± 14 years. Brain injury secondary to head trauma was the main indication for craniectomy, especially traffic accidents (car and motorcycle accidents represented 24% of our population) followed by falls (13.79%) [
Data regarding medical condition before cranioplasty is shown in
Most cranioplasties were right hemicraniectomy reconstruction (48.28%), followed by left and frontal reconstruction. Only 5 patients had bone failure size smaller than 75 cm2, and 91% harbored a moderate or large cranial bone defect [
Cranioplasty complications are described in
Analyzing the 2 patients who had epidural hematoma, authors identified that 1 case occurred in late after thesurgery (40 days postoperative) secondary to a de novo traumatic brain injury. The second patient was due to inadvertently anticoagulant reintroduction in the immediate postoperative period.
Two patients were operated because of infected epidural collection. One patient was previously submitted to a bifrontal reconstruction with exposition of the frontal sinus, and developed a Staphlycoccus aureus infection (bacteria identified in the epidural liquid culture). It is noteworthy to mention that the patient constantly explored the wound with the nails. In this case, drainage of the collection was performed without removal of the PMMA. The other patient had a ventricular peritoneal deviation (VPD) previous to cranioplasty, and developed epidural collection postoperative. In order to accelerate collection absortion, authors changed shunt valve to a high pressure system. After the exchange, the patient suffered a minor traumatic brain injury with increase in epidural collection. At this moment, authors decided to close the shunting, howevern hydrocephalus and subcutaneous collection increased, developing surgical site infection. The patient required reoperation to drain the collection, staying with high-pressure shunt, which resolved the infection and hydrocephalus.
Central scalp necrosis was a complication presented by one patient with previously damaged skin secondary to trauma mechanism. Skin necrosis with exposed CP plate required a plastic surgery to rebuild surgical site with skin flap rotation, without removing PMMA prosthesis. Out of the 5 patients reapproached, only 1 had the CP plate removed.
Ten patients had minor complications (16.1%); 2 cases of surgical wound dehiscence, 1e case of phlebitis in the right upper limb, and 7 patients (11%) had seizures.
Even though the authors did not consider a postoperative complication, the presence of epidural collection underneath PMMA plaque in the immediate postoperative cranial CT scan was found in 56.4% of patients. Spontaneous absorption occurred in most cases during follow up, and only 9 patients still had epidural collection in the 12 month postoperative CT scan [
The elevated incidence of infection after cranioplasty is a subject that instigates neurosurgeons, especially because it is an elective, controlled, aseptic procedure. Therefore, incidence of up to 20% described in medical literature should not be common.[
In the scenario described here, it is important to find out new techniques to optimize the procedures previously described to diminish the number of postcranioplasty infection rate. The use of prostheses with antibiotics is an established procedure in many orthopedic surgeries. Authors chose the antibiotics erythromycin and colistin based on the bacterial spectrum of coverage offered by these antibiotics in association (erythromycin has a coverage for Gram-positive organisms such as Staphylococcus spp and Streptococcus spp, whereas colistin has a Gram-negative coverage over Escherichia coli, Enterobacter, Klebsiela Pseudomonas).
Analyzing possible risk factors to explain the higher incidence of infection after cranioplasty, the items usually associated with higher risks are timing of surgery (early versus late), cranial defect location, surgical site conditions (skin and subcutaneous state), and the presence of other catheters (VPD).
There is no consensus in medical literature to define early cranioplasty, however, most articles describe that cranial bone reconstruction performed up to 3 months of craniectomy as early surgeries. Late cranioplasty has lower incidence of infection when compared to early procedures. A possible explanation for this finding is a bacterial overgrowth after the first surgical procedure when the aseptic conditions may reduce the proportion of bacteria from the skin microbiota which increases the proportion of pathogenic germs, increasing the risks of infection in a second skin incision.[
Skull location of cranioplasty influences the infection risks, as described by Gooch et al.[
Seven patients (11%) in this series were victims of frontal defect, 2 with large bifrontal skull defect. During surgery, frontal sinus was exposed in 5 of the patients (8% of total), however, none of them developed postoperative infection. One patient with large bifrontal defect, without sinus communication, developed post-surgical infection, which corroborates the high incidence of infection among these patients.
Hostile surgical local for cranioplasty is described as tissues previously submitted to radiation therapy, with active infection or cerebrospinal fluid leaks, the presence of skin lesions or scars secondary to the head trauma. Eight patients (13%) who presented at least one of the conditions described above were submitted to cranioplasty in our study; 3 patients had previous head radiation therapy, 2 had previous osteomyelitis, 2 had subdural empyema, and 1 patient had failure of previous cranioplasty. None of these 8 patients developed any kind of postoperative complications.
The presence of ventricular peritoneal shunt is believed to be a risk factor for postoperative infection in the shunting system as well as in the cranioplasty, either by direct surgical contamination or hematogenous bacteria spread.[
The most common complication in our population was the presence of liquid collection underneath PMMA plaque. This finding occurred in 35 (56.4%) patients, even though all cases had aspiration drain located in the epidural space during a mean duration of 36 hours and the dura mater was anchored in the PMMA plaque. According to medical literature, epidural liquid formation may be a normal body reaction to the presence of a synthetic material in contact to the dura mater and subcutaneous tissues. Therefore, many authors do not classify this finding as a surgical complication because the liquid is not infected and do not cause any symptoms.
A retrospective study conducted by Chang et al.,[
The association of epidural collection with the size of cranial defect reconstruction had already been described.[
A total of 15 patients in our series developed some type of post-surgical complication, 5 cases had major and 10 minor complications. Among the 5 patients with major complications requiring surgical reintervention, only 1 case had the cranioplasty plaque removed. The patient who evolved with skin necrosis and PMMA plaque exposition was submitted to a plastic skin rotation with satisfactory result, with no need of prostheses removal. Among 10 patients with minor complications 7 had seizures, 2 had surgical wound dehiscence, and 1 had phlebitis.
Global postoperative surgical site infection rate in this study was 3.2%, a very low rate when compared to other articles, where incidences reached 20% or more.[
Authors believed that the predominance of large skull defects requiring long surgical time and the elevated proportion of postoperatory epidural fluid collection could increase the incidence and risks of infection. The constrasting and surprising low incidence of infection in this scenario may be secondary to the use of PMMA plaques imbibed with antibiotics.
Even though the autologous bone graft is still the preferred method for cranial defect reconstruction, the infection risks, bone absorption, the limitation of donator area, and bone tissue loss in comminous fractures are situations that require defect reconstruction with synthetic materials. Among the many possible materials for skull reconstruction, PMMA is one of the most frequently used because its possibility of molding the defect, material resistance, and satisfactory aesthetic results.[
One of the study limitation is the nonexistence of a control group; moreover, the authors did not dose antibiotic blood concentration after the surgery, which would demonstrate a systemic or just local impact of antibiotic use. Another limitation is that all surgeries were performed months after prior craniectomy (late cranioplasty) when the risks of complications and infection are possibly lower when compared to early cranioplasty, although recent systematic reviews did not support this information.[
The use of antibiotic-impregnated PMMA for correction of moderate and large skull defects had a low incidence of infectious postoperative complications. This association may be useful to reduce the morbidity and mortality as well as hospital costs, especially in medical centers where a higher complication rate is expected.
Financial support and sponsorship
Conflicts of interest
There are no conflicts of interest.
1. Al-Tamimi YZ, Sinha P, Trivedi M, Robson C, Al-Musawi TA, Hossain N. Comparison of acrylic and titanium cranioplasty. Br J Neurosurg. 2012. 26: 510-3
2. Bobinski L, Koskinen L-OD, Lindvall P. Complications following cranioplasty using autologous bone or polymethylmethacrylate-Retrospective experience from a single center. Clin Neurol Neurosurg. 2013. 115: 1788-91
3. Chang V, Hartzfeld P, Langlois M, Mahmood A, Seyfried D. Outcomes of cranial repair after craniectomy. J Neurosurg. 2010. 112: 1120-4
4. Cheng YK, Weng HH, Yang JT, Lee MH, Wang TC, Chang CN. Factors affecting graft infection after cranioplasty. J Clin Neurosci. 2008. 15: 1115-9
5. Coulter IC, Pesic-Smith JD, Cato-Addison WB, Khan SA, Thompson D, Jenkins AJ. Routine but risky: A multi-centre analysis of the outcomes of cranioplasty in the Northeast of England. Acta Neurochir. 2014. 156: 1361-8
6. Stula D.editorsCranioplasty Indications, Technique and Results. Viena: Springer-Verlag; 1984. p.
7. Gilardino MS, Cabiling DS, Bartlett SP. Long-term follow-up experience with carbonated calcium phosphate cement (Norian) for cranioplasty in children and adults. Plast Reconstr Surg. 2009. 123: 983-94
8. Gooch MR, Gin GE, Kenning TJ, German JW. Complications of cranioplasty following decompressive craniectomy: Analysis of 62 cases. Neurosurg Focus. 2009. 26: E9-
9. Hall WA. Cranioplasty infections-adding insult to injury. World Neurosurg. 2014. 82: e435-7
10. Im SH, Jang DK, Han YM, Kim JT, Chung DS, Park YS. Long-term incidence and predicting factors of cranioplasty infection after decompressive craniectomy. J Korean Neurosurg Soc. 2012. 52: 396-403
11. Jüttler E, Unterberg A, Woitzik J, Bösel J, Amiri H, Sakowitz OW. Hemicraniectomy in Older Patients with Extensive Middle-Cerebral-Artery Stroke. N Engl J Med. 2014. 370: 1091-100
12. Kim SP, Kang DS, Cheong JH, Kim JH, Song KY, Kong MH. Clinical analysis of epidural fluid collection as a complication after cranioplasty. J Korean Neurosurg Soc. 2014. 56: 410-8
13. Klinger DR, Madden C, Beshay J, White J, Gambrell K, Rickert K. Autologous and acrylic cranioplasty: A review of 10 years and 258 cases. World Neurosurg. 2014. 82: e525-30
14. Kung WM, Lin MS. A simplified technique for polymethyl methacrylate cranioplasty: Combined cotton stacking and finger fracture method. Brain Inj. 2012. 26: 1737-42
15. Matsuno a, Tanaka H, Iwamuro H, Takanashi S, Miyawaki S, Nakashima M. Analyses of the factors influencing bone graft infection after delayed cranioplasty. Acta Neurochir. 2006. 148: 535-40
16. Moreira-Gonzalez A, Jackson IT, Miyawaki T, Barakat K, DiNick V. Clinical Outcome in Cranioplasty: Critical Review in Long-Term Follow-Up. J Craniofac Surg. 2003. 14: 144-53
17. Piitulainen JM, Kauko T, Aitasalo KM, Vuorinen V, Vallittu PK, Posti JP. Outcomes of cranioplasty with synthetic materials and autologous bone grafts. World Neurosurg. 2015. 83: 708-14
18. Rosseto RS, Giannetti AV, de Souza Filho LD, Faleiro RM. Risk Factors for Graft Infection After Cranioplasty in Patients with Large Hemicranial Bony Defects. World Neurosurg. 2015. 84: 431-7
19. Schuss P, Vatter H, Marquardt G, Imöhl L, Ulrich CT, Seifert V. Cranioplasty after Decompressive Craniectomy: The Effect of Timing on Postoperative Complications. J Neurotrauma. 2012. 29: 1090-5
20. Shah AM, Jung H, Skirboll S. Materials used in cranioplasty: A history and analysis. Neurosurg Focus. 2014. 36: E19-
21. Shiono Y, Watanabe K, Hosogane N, Tsuji T, Ishii K, Nakamura M. Sterility of posterior elements of the spine in posterior correction surgery. Spine. 2012. 37: 523-6
22. Tsang AC, Hui VK, Lui WM, Leung GK. Complications of post-craniectomy cranioplasty: Risk factor analysis and implications for treatment planning. J Clin Neurosci. 2015. 22: 834-7
23. Wachter D, Reineke K, Behm T, Rohde V. Cranioplasty after decompressive hemicraniectomy: Underestimated surgery-associated complications?. Clin Neurol Neurosurg. 2013. 115: 1293-7
24. Walcott BP, Kwon C-S, Sheth SA, Fehnel CR, Koffie RM, Asaad WF. Predictors of cranioplasty complications in stroke and trauma patients. J Neurosurg. 2013. 118: 757-62
25. Xu H, Niu C, Fu X, Ding W, Ling S, Jiang X. Early cranioplasty vs. late cranioplasty for the treatment of cranial defect: A systematic review. Clin Neurol Neurosurg. 2015. 136: 33-40
26. Yadla S, Campbell PG, Chitale R, Maltenfort MG, Jabbour P, Sharan AD. Effect of early surgery, material, and method of flap preservation on cranioplasty infections: A systematic review. Neurosurgery. 2011. 68: 1124-9